• 主题
高级搜索  >
历史搜索 清空历史
首页> 外文会议>The 22nd International Conference on Solid Waste Technology and Management(ICSW 2007) >Investigation of Petrochemical Ashes as Cement Additives on Gas Migration through Cement Slurry
【24h】

Investigation of Petrochemical Ashes as Cement Additives on Gas Migration through Cement Slurry

机译：石化灰作为水泥添加剂对水泥浆中气体迁移的研究

获取原文
获取原文并翻译 | 示例
页面导航
  • 摘要
  • 著录项
  • 相似文献
  • 相关主题

摘要

Gas migration problem after cementing the producing casing in oil /gas drilled wells is well known and costly for industry and also it is extremely difficult to prevent. The main objective of this research was to investigate the method to modify the cement properties in order to prevent gas migration during cement slurry and after cement set job. In Bandar Imam Petrochemical Company) BIPC) of Iran, waste products from polymer units are transmitted to an incinerator and are burned. The ash products from the incinerator are discharged to environment near by the company. Since the produced ash can cause the environmental damages, an attempt was made to use the ash as cement additive for oil/gas drilling wells. By sampling produced ash in periodic times and collecting all cement additives used in drilling / completion cement jobs in Iranian drilling operation, the effects of the ash on cement properties were experimentally investigated.rnIn this paper several tests were performed to study ash effects on physical properties of cement slurry and set cement. The parameters investigated in this paper were: rheology properties, fluid loss, permeability and porosity. Test results indicated that the use of ash as additive for cement class D as shown cause to increasing in GS and PV. The increasing GS and PV of cement by ash additives resulted to prevent gas migration through cement slurry. The addition of ash to class D cement causes to decrease the fluid loss considerably. Also permeability and porosity of set cement decreased with respect to increasing the concentration of ash in cement. These results have indicated, with increase of added ash to cement class G, the behavior of cement advances to eliminate of gas migration through cement as same as common additives used for cementing job in drilling industry.
机译：在石油/天然气钻井中将生产套管固井之后的气体迁移问题是众所周知的，并且对于工业而言是昂贵的，并且也很难预防。这项研究的主要目的是研究改变水泥性能的方法，以防止水泥浆和凝结后的气体迁移。在伊朗的班达伊玛目石化公司（BIPC），聚合物单元产生的废物被输送到焚化炉进行燃烧。焚烧炉产生的灰渣被公司排放到附近的环境中。由于产生的灰烬可能对环境造成破坏，因此尝试使用该灰烬作为石油/天然气钻井的水泥添加剂。通过定期对产生的灰分进行采样并收集伊朗钻井作业中钻井/完井水泥作业中使用的所有水泥添加剂，实验研究了灰分对水泥性能的影响。本文进行了一些测试，研究了灰分对物理性能的影响水泥浆和凝结水泥。本文研究的参数为：流变性质，流体损失，渗透率和孔隙率。测试结果表明，使用灰分作为D类水泥的添加剂会导致GS和PV的增加。灰分添加剂增加了水泥的GS和PV，从而防止了气体通过水泥浆的迁移。在D级水泥中添加灰分可显着减少流体损失。相对于增加水泥中灰分的浓度，凝固水泥的渗透性和孔隙率也降低了。这些结果表明，与添加到G级水泥中的灰分相比，水泥的行为得以改善，从而消除了气体通过水泥的迁移，这与钻井行业中用于水泥作业的普通添加剂相同。

著录项

相似文献

  • 外文文献
  • 中文文献
  • 专利
获取原文

客服邮箱：kefu@zhangqiaokeyan.com

京公网安备：11010802029741号 ICP备案号：京ICP备15016152号-6 六维联合信息科技 (北京) 有限公司©版权所有

  • 客服微信

  • 服务号