Highly active CNT-promoted co-precipitated Cu-ZnO-Al2O3 catalysts, symbolized asCuiZnjAlk-x%CNTs, were prepared, and their catalytic activity for once-through methanol synthesis fromsyngas was investigated. The results illustrated that, under the reaction conditions (at 493 K, 5.0 MPa, thevolume ratio of H2/CO/CO2/N2＝ 62/30/5/3, GHSV＝ 4000 h-1), the observed single-pass CO-conversionand methanol-STY over a Cu6Zn3Al1-12.5%CNTs catalyst reached 64% and 1210 mg/(h@g), which wasabout 68% and 66% higher than those (38% and 730 mg/(h@g)) over the corresponding CNT-free catalyst,Cu6Zn3Al1, respectively. The characteristic studies of the catalysts revealed that appropriate incorporationof a minor amount of the CNTs into the CuiZnjAlk brought about little change in the apparent activationenergy of the methanol synthesis reaction, however, led to a considerable increase in the catalyst's active Cusurface area and pronouncedly enhanced the stationary-state concentration of active hydrogen-adspecieson the surface of the functioning catalyst, which would be favorable to increasing the rate of the CO hydro-genation reactions. Moreover, the operation temperature for methanol synthesis over the CNT-promotedcatalysts can be 10-20 degrees lower than that over the corresponding CNT-free contrast system, whichwould contribute considerably to an increase in equilibrium CO-conversion and CH3OH-yield.
展开▼
